The results showed that the lime consumption was reduced from 65~70kg to 50~55kg per one ton steel,the slag consumption was reduced from 95~105kg to 80~90kg per one ton steel,the slag basicity was reduced to 2.
介绍安钢第一炼轧厂100 t转炉在生产中实施小渣量操作,吨钢石灰加入量由65~70 kg降低至50~55kg,渣料消耗由90~105 kg降低至75~90 kg,使炉渣碱度降至2。
Based on the mass balances of blast furnace,typical slag basicity was calculated and analyzed in different zones of the blast furnace.
根据高炉的炉料平衡,对典型高炉不同区域内的炉渣碱度进行计算。
In this presentation,the effects of LF-slag oxygenation,slag basicity,consumption per ton on the slag sulphur capacity were analyzed and discussed in the process of LF refining treatment.
本文结合生产试验对LF炉精炼工艺中的炉渣氧化性控制,吨钢渣料消耗、炉渣碱度对炉渣硫容量的影响等问题进行分析与探讨,以期在此基础上对本厂LF精炼炉渣的改进提供指导,达到精炼目的,满足连铸生产对钢水质量的要求。
Behavour of Non-metallic Inclusions in Liquid Alloy Steel under High Basicity High Al_2O_3 Slag;
高碱度高Al_2O_3炉渣下合金钢液中非金属夹杂物的行为
Influence of Metal Temperature,Slag Basicity and Initial Si Content on Demanganization of Carbon-Saturated Hot Metal
铁水温度、炉渣碱度和初始硅含量对碳饱和铁水脱锰的影响
Effect of TiO_2 Content and Basicity on Shuigang BF Slag Fluidity
碱度和TiO_2含量对水钢高炉炉渣流动性的影响
Experiment on the low alkalinity steel slag as mineral admixture
低碱度转炉钢渣用作矿物掺和料的试验研究
basic principle
基本原理basicdyes碱性染料basicslag碱性转炉渣
The phosphur content of steel at blowing end can reach predetermined level by proper control on the FeO content and basicity of slag.
适当控制炉渣的氧化铁和碱度可使吹炼终点磷含量达到预定值。
Erosion of refractory by the ultra-high alkalinity slag produced in smelting ores from Guangxi
广西矿冶炼中超高碱度炉渣对耐火材料的侵蚀性研究
Study on Mass Action Concentration of TiO_2 and Slag Viscosity for Ti-containing Slag;
含钛炉渣中TiO_2作用浓度及炉渣粘度研究
THERMODYNAMICS OF LIQUID BLAST-FURNACE-TYPE SLAGS Ⅱ.THE APPLICATION OF A NEW BASICITY RATIO TO DESULFURIZATION OF CARBON-SATURATED IRON
液态高炉型熔渣的热力学——Ⅱ.一个新的碱度公式在生铁脱硫平衡方面的应用
blast-furnace cinder
高炉矿渣, 鼓风炉炉渣
Study on Metallurgical Properties of Blast Furnace Burden and Slag Viscosity in Nanjing Iron and Steel Corporation;
南钢高炉炉料冶金性能及炉渣粘度研究
The Separation of Primary Mineral Phase in Granulated Blast-furnace Slag;
粒化碱性高炉矿渣中原始矿物相的形成研究
Performance Research of Weakly Alkalinity Alkali-Activated Slag Cement Immobilsing Nuclear Wastes;
低碱度碱矿渣水泥固化放射性废物性能研究
Thermal simulation and analysis of BOF under slag splashing condition
溅渣护炉状态下转炉温度场的模拟分析
Mechanism of Increasing Concrete Strength by Titanium Contained Blast Furnace Slag
高炉钛渣提高混凝土强度的作用机理
A study on synthetic activity of mixture of fly ash, grained basic slag and silica fume
粉煤灰、粒化碱性高炉渣、硅粉的可互补性和协合研究
The experiments on the separation of slag from hot metal during smelting with full V-Ti iron ore were carried out.
高炉冶炼全钒钛铁矿时通过改变造渣制度进行渣铁分离实验。
Experimental Investigation on Mechanism and Critical Temperature for Coal Ash Slagging on the Combustion-belt Materials
燃煤锅炉卫燃带结渣机理及结渣临界温度的实验研究
Study on optimum burning temperature of white cement by soda residue
碱渣烧制白色水泥适宜煅烧温度的研究